Commerical Kitchen Floor Cleaning

The Quarry tiles shown below were installed in the kitchen of a take away restaurant near Hockliffe, as you can see they were quite tarnished and not looking their best due to general wear and tear and the use of strong cleaning products; an inspection was also due and the proprietor was concerned it would be an issue.

Cleaning Quarry Tiles at Hockliffe Takeaway Before

Cleaning Quarry Tiles

To clean the floor tile and grout I decided to apply a strong combination of Tile Doctor Pro-Clean mixed 50/50 with NanoTech Ultra Clean and then diluted with water. This combination creates a powerful cleaning product containing nano sized abrasive particles that can penetrate deep into the dirt. The cleaning solution was left to dwell on the surface of the tile for twenty minutes before scrubbing with a rotary machine fitted with a black scrubbing pad and then washed off with a Rotovac machine which applies and removes hot water at high pressure effectively cleaning the tile and grout and rinsing then removing the water at the same time.

Cleaning Quarry Tiles at Hockliffe Takeaway After

Sealing Quarry Tiles

Once we were happy with the Quarry tile and grout was clean we left the floor to dry assisted with air blowers to speed up the process. It wasn’t long before it had dried and we were then able to the Tile and Grout using Tile Doctor High Shine sealer which should protect the floor for at least three years given the high traffic, this is of course as long as they use the correct cleaning products as acidic products will reduce the life of a sealer. The kitchen was now ready for inspection where it should pass with flying colours.

Source: Cleaning Takeaway Kitchen Tiles Prior to Inspection in Bedfordshire

Commerical Grade Terrazzo Floor restored at Wigan Chip Shop

These photographs are of a Stained Terrazzo Tiled floor from an old Fish and Chip shop in Wigan which had been closed for several months due to the owner being ill. The shop had then been sold and the new owners asked us to call in and re-furbish the tired and badly stained tiles rather than go to the expense of re-tiling or re-surfacing the Floor area, which would have cost a lot more than what we charged.

Terrazzo Tile at Wigan Fish and Chip Shop Before Terrazzo Tile at Wigan Fish and Chip Shop Before

Terrazzo is a composite tile made up of Marble and Limestone chippings, sometime Granite, all mixed into a clear cement resin and then made up into tiles of all sizes. We estimated these tiles we laid more than fifty years prior and were not looking their best after being stained with rust stains from heavy equipment, cooking oil and grease, ingrained dirt and grime. Although a tough job to tackle it didn’t put us off and as you will see we still managed to get them clean again.

Cleaning Terrazzo Tile

The method we used to restore the surface was to cut them back using a set of burnishing pads which take off a few millimetres off the tile surface and regrinds to make them look as good as new, this is something you can’t do with Vinyl Tiles or Ceramic and Porcelain. The pads are encrusted with diamonds and are used in conjunction with a little water; you start with a coarse pad and work through the set of pads which become finer in grade as you progress until your polishing the surface. Once this process is complete the floor was given a good wash down to remove any soil and allow us to spot any areas that needed further attention.

Sealing Terrazzo Tile

When the Terrazzo tile was dry it was sealed sealing with two coats of Tile Doctor Colour Grow which is an impregnating matt sealer that brings out the colours in natural stone, the client had also specified they didn’t want a shiny finish as they had a concern about slippery surface that could lead to slips and falls. Once the sealer was dry it was buffed using a white buffing pad.

Terrazzo Tile at Wigan Fish and Chip Shop After Terrazzo Tile at Wigan Fish and Chip Shop After

The results are quite satisfying given the age of the floor and the stains we had to deal with not only that but the owner had engaged a number of other cleaning companies who had tried a test clean and he had even tried cleaning it himself but the results were poor.

Terrazzo Tile at Wigan Fish and Chip Shop Completed

 
 
Source: Commerical Tile and Stone Cleaning Services in Lancashire

2014 Tile Doctor Conference

This year’s Tile Doctor Conference will be held on the 10th of May at The Radisson Park Inn in York.  It’s within 5 minutes walking distance from the main train station and we have managed to agree a special rate with the hotel if you book before February 14th.

The proposed conference Itinerary includes:

  • Delegates arrive for 12:30, teas and coffees on arrival
  • Conference starts at 1pm;
  • New Product Introduction and updates.
  • Talk on Surface Tension on Stone Tiles
  • Guest Speaker
  • Marketing updated.
  • Tile Doctor Award Ceremony 2014
  • 5p.m Buffett Banquet.
  • Wooden Spoon Awards 7p.m Finish

For the evening entertainment we are planning an evening of distraction around York taking in some of its famous sites.

 This is a great opportunity to get to know other Tile Doctors, share information, tips and network with like-minded individuals in your sector.

 Space in the venue is limited so please call the office to reserve your seat.

pd-rd-logo[1]